HVAC SYSTEM PERFORMANCE - LEARNING ZONES

Created by ChecklistGuro (https://checklistguro.com)

--- ZONE TEMPERATURE & HUMIDITY ---
[ ] Zone Setpoint Temperature (Current)
[ ] Zone Temperature (Actual)
[ ] Zone Humidity (Current)
[ ] Humidity Setpoint
[ ] Temperature Comfort Level (Too Cold, Comfortable, Too Warm)
[ ] Humidity Comfort Level (Too Humid, Comfortable, Too Dry)
[ ] Notes/Observations about Temperature & Humidity
[ ] Date of Measurement
[ ] Time of Measurement

--- AIRFLOW AND VENTILATION ---
[ ] Measured Airflow (CFM) at Supply Diffuser 1
[ ] Measured Airflow (CFM) at Supply Diffuser 2
[ ] Room Air Changes per Hour (ACH)
[ ] Supply Diffuser Orientation (Typical) (Horizontal, Vertical, Angled)
[ ] Observed Airflow Issues (Drafts, Uneven Temperature Distribution, Insufficient Ventilation, Excessive Noise, None)
[ ] Description of any observed airflow irregularities.
[ ] Exhaust Fan Operational Status (Operational, Not Operational, Partial Operational)
[ ] Measured Static Pressure (inches of water)

--- EQUIPMENT PERFORMANCE (AHUS, FCUS, VRFS) ---
[ ] AHU/FCU Supply Air Temperature (SAT) - Zone 1 (°F)
[ ] AHU/FCU Return Air Temperature (RAT) - Zone 1 (°F)
[ ] VRF Outdoor Unit Suction Pressure (psig) - Zone 2
[ ] FCU Fan Speed (RPM) - Zone 3
[ ] AHU/FCU Compressor Status (Zone 1) (Operating Normally, Fault/Alarm, Degraded Performance)
[ ] VRF Indoor Unit Defrost Cycle Status (Zone 1) (Normal, Frequent, Extended)
[ ] Observed Operational Issues/Notes (AHU/FCU/VRF)
[ ] Date of Last Filter Replacement (AHU/FCU)

--- CONTROL SYSTEM OPERATION ---
[ ] Scheduled Start Time (Hour)
[ ] Scheduled Stop Time (Hour)
[ ] Operating Mode (Cool, Heat, Auto, Off) (Cool, Heat, Auto, Off)
[ ] Zone Temperature Setpoint (°C)
[ ] Outdoor Air Damper Position (%)
[ ] Demand Limiting Activated? (Yes, No, N/A)
[ ] Notes on Control System Behavior

--- NOISE AND VIBRATION LEVELS ---
[ ] Ambient Noise Level (dB)
[ ] Equipment Vibration Level (mm/s)
[ ] Noise Source Identification (HVAC Equipment, Piping, External Sources (Traffic, Construction), Other - Please Specify)
[ ] Detailed Description of Noise/Vibration Issues (if any)
[ ] Perceived Noise Level (Subjective) (Acceptable, Slightly Noticeable, Distracting, Unacceptable)
[ ] Noise/Vibration Source Location
[ ] Sound Recording (Optional)

--- AIR QUALITY ---
[ ] CO2 Level (ppm)
[ ] PM2.5 Concentration (µg/m³)
[ ] PM10 Concentration (µg/m³)
[ ] Presence of Visible Particulates? (Yes, No, Uncertain)
[ ] Odor Detected? (Yes, No, Uncertain)
[ ] Describe any unusual odors or conditions observed:
[ ] Photos/Videos of Air Quality Concerns:
[ ] Date of Air Quality Assessment

--- ENERGY CONSUMPTION ---
[ ] Average Monthly kWh Consumption (Learning Zones)
[ ] Peak Hourly kWh Consumption (Learning Zones)
[ ] Energy Consumption per Square Foot/Meter (Learning Zones)
[ ] Current Energy Tariff Type (Fixed Rate, Variable Rate, Time-of-Use, Demand Charge)
[ ] Notes on Energy Consumption Trends (e.g., increase/decrease, anomalies)
[ ] Date of Last Energy Consumption Baseline Measurement
[ ] Upload Energy Bill/Consumption Data Report (if available)

--- MAINTENANCE & SERVICE RECORDS ---
[ ] Last Filter Replacement Date (Zone 1)
[ ] Last Filter Replacement Date (Zone 2)
[ ] AHU/FCU Static Pressure (in WC)
[ ] Supply Air Temperature (in °F/°C)
[ ] Condition of Belts/Pulleys (AHU/FCU) (Good, Fair, Poor)
[ ] Notes on Recent Servicing (if any)
[ ] Refrigerant Leak Check Performed? (Yes, No)
[ ] Upload Service Reports (if applicable)

--- END OF TEMPLATE ---
Transform this text into a digital, automated, and trackable mobile app!
Visit: https://checklistguro.com/templates/facility-management/hvac-system-performance-learning-zones
(Click "Install Template" to launch your digital inspection tool immediately)